Product ID:TYPE II WALKWAY DARK GULL GRAY, G-8130
MSDS Date:03/29/2000
FSC:8010
NIIN:00-641-0426
Status Code:A
MSDS Number: CKYSL

AKRON PAINT AND VARNISH INC

1390 FIRESTONE PARKWAY
AKRON, OH 44301-1624
US

Emergency Phone: (800)424-9300

Info Phone: 216-773-8911

Preparer: HENRY SIMMONS

Cage: 70228

AKRON PAINT AND VARNISH INC

AKRON, OH 44301-1624 US

Telephone: 216-773-8911

Cage: 70228

LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM)

CAS: 64742-89-8

CRYSTALLINE SILICA

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Effects of Overexposure:EYES: CAN CAUSE REDNESS, IRRITATION, SWELLING
AND BLURRED VISION. SKIN: PROLONGED OR
REPEATED CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS
BREATHING:EXCESSIVE INHALATION OF VAPORS A ND/OR SPRAY MIST CAN
CAUSE RESPIRATORY IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS AND
EVEN
ASPHYXIATION. SWALLOWING: CAN CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VO MITING
AND DIARRHEA; ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS
WHICH COULD BE FATAL.

First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES. LIFT
EYELIDS OCCASIONALLY,
GET PROMPT MEDICAL ATTENTION. SKIN: WASH THOROUGHLY WITH SOAP AND
WATER, REMOVE
CONTAMINATED CLOTHING PROMPTLY; WASH CLOTHING BEFORE REUSE. CONSULT A
PHYSICIAN IF
IRRITATION PERSISTS.SWALLOWING: SINCE THIS PRODUCT MAY CONTAIN
MATERIALS, WHICH CAN
CAUSE LUNG DAMAGE IF ASPIRATED INTO THE LUNGS, THE DECISION WHETHER T O
INDUCE
VOMITING MUST BE MADE BY A PHYSICIAN AFTER CAREFUL CONSIDERATION OF ALL
MATERIALS
INGESTED. INHALATION: MOVE AFFECTED PERSON TO FRESH AIR. IF BREATHING
HAS STOPPED,
GIVE ARTIFICIAL RESPIRATI ON.

Flash Point Method:SCC
Flash Point:=10.C, 50.F
Lower Limits:0.9%
Upper Limits:12.3%
Extinguishing Media:CARBON-DIOXIDE-DRY CHEMICAL-FOAM-WATER FOG USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER OR POSITIVE
PRESSURE MODE. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND TO AN IGNITION SOURCE SOME DISTANCE FROM
MATERIAL HANDLING POINT. IGNITION SOURCES INCLUDE PILOT LIGHTS,
SMOKING, HEATERS, ELECTRIC MOTORS, SPARKS FROM ELECTRICAL SWITCHES
AND STATIC DISCHARGES.

Spill Release Procedures:SMALL SPILL: ABSORB LIQUID WITH RAGS, FLOOR
ABSORBENT, VERMICULITE OR OTHER
ABSORBENT MATERIAL AND TRANSFER TO HOOD. LARGE SPILL: ELIMINATE ALL
IGNITION
SOURCES?DIKE AREA OF SPILL TO PREVENT SPREADIN G?VENTILATE AREA IF
INDOORS---PUMP
LIQUID INTO SALVAGE TANK?REMAINING LIQUID MAY BE TAKEN UP WITH SAND,
FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL AND SHOVELED INTO CONTAINER.

Handling and Storage Precautions:DO NOT DROP CONTAINERS. AVOID HEAT,
SPARKS, AND OPEN FLAME. STORE LARGE QUANTITIES
ONLY IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106. NEVER USE
PRESSURE TO EMPTY.
AVOID BREATHING SANDING DUST. D O NOT HANDLE UNTIL THE MANUFACTURERS
SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
Other Precautions:THE INFORMATION ACCUMULATED HEREIN IS BELIEVED TO BE
ACCURATE BUT IS NOT
WARRANTED TO BE WHETHER ORIGINATING WITH THE COMPANY OR NOT. RECIPIENTS
ARE
ADVISED TO CONFIRM IN ADVANCE OF NEED THAT THE INFO RMATION IS CURRENT,
APPLICABLE,
AND SUITABLE TO THEIR CIRCUMSTANCES.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS WITH UNRESTRICTED
VENTILATION APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE
A COMBINATION OF PARTICULATES AND VAPOR.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP AIR CONTAMINANT CONCENTRATION BELOW CURRENT APPLICABLE OSHA
PERMISSIBLE EXPOSURE LIMIT.
Protective Gloves:WEAR RESISTANT GLOVES SUCH AS: NITRILE RUBBER.
Eye Protection:CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA
REGULATIONS ARE ADVISED.
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health

Boiling Pt:=115.6C, 240.F
B.P. Text:240-285F
Vapor Pres:HEAVIER THAN AIR
Spec Gravity:1.318
VOC Grams/Liter:3.35
Appearance and Odor:LIQUID AND GRAY
Percent Volatiles by Volume:53.44

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS (E.G. NITRIC ACID)
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE,
VARIOUS HYDROCARBONS, ETC

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTINNG REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT ACT OF 1986 AND 40 CFR
372: XYLENE- CASS NUMBER 1330-20-7, 1.19 PERCENT. SARA TITLE III
SECTION 313: PROP 65 (CARCINOGEN): PROP 65 (TETRATOGENIC): PROP 65
(BOTH CARCINOGEN AND TETRATOGENIC).
State Regulatory Information: